Odessa, Ukraine.

Afina 6th Floor, Office 625, 65054

Mon - Fri: 9:00 - 17:30

Online support always open

10 Major source of fire out break onboard ship

source of fire onboard ship

In a vessel surrounded by water,could be a major source of fire and fire may be the last on crews list of suspected onboard hazards.

However, ships are susceptible to source of fire due to the amount of heavy machinery installed.

Unlike land based fire, a ship’s crew are not able to walk away druing fire incident at sea and/or rely upon the local Fire Department to extinguish it or evacuation of individual on risk zone. With limited resources, crews are expected to deal with fire incidents that would test even the most experienced of fire fighters.

Determining the causes of fire outbreak or source of fire, one need to identify the present of the main ingredient of fire which includes ; Air, fuel and heat to ignite and sustain their flames. All ships have all three of the above fire ingredients, therefore best way to deal with fires on board ships is to prevent them rather than letting them occur.

Also see Easy way to pass annual ship survey

In tanker vessels, fire outbreak is a very big hazardous moment… especially if the Ignition point ( breaking out of fire in a place where no fire exist) was not quickly arrested, which could lead to flash over ( fire eruption in a new place as a result of flames from an existing fire in a nearby place of ignition source). If it affects an enclosed cargo tank, it could lead to explosion, uncontrollable fire, etc.

Main source of fire outbreak on board ship

Looking into the main source of fire areas in a ship or where it could break out; it’s incorporate with the amount of fire ingredients present in the area( such as fuel, electrical cables/motors, temperature (°C), etc. The areas includes;

1. Ship Engine Room

2. Pumps Room

3. Chain locker or fore peak

4. Deck stores/paint room

5. Galley (ship kitchen)

6. Accommodation (crew cabin’s)

7. Incinerators (An apparatus for burning waste materials onboard ship)

8. Boiler Space

9. Fuel purification room

10. Emergency generator room

According to the UK P&I, the major source of fire and/or fire incidents always start from engine room, boiler Space, purifier room, incinerator space, accommodation  and cargo pump room( in terms of tanker ships.

In other to prevent fire outbreak from these main points, there’s need to maintain the following routines;

1. Any fuel leakages found should be investigated and dealt with immediately.

2. Proper routine inspection on piping works and screening arrangements for deterioration.

3. The officers in charge should ensure that the insulation covering heated surfaces is always in good condition.

4. The officers to carry out regular testing that passive safety devices such as fire dampers, flaps and quick closing valves are in good condition and fully operational (for easy control of two fire ingredients).

5. Combustible material or flammable compounds, woodwork, hose,Freon and compressors should be stored in a proper place ( not in the machinery space).

6. Spot and identify inadequate insulation and hot surfaces by using thermal imaging at regular intervals.

7. Fire detector should be in working condition and the engine alarm system is fully functional. Always investigate alarms thoroughly and take prompt action before clearing the alarm status (mainly fire alarm).

8. The ability of the senior officers to conduct regular fire drill is very important for training and familiarity of fire fighting equipments. The drill most impact in response time incase of fire.

9. CO2 room and other portable extinguishers should be ready at all times.

For Boat owners see: Mini Firefighter All Purpose Fire Extinguisher Classes ABCK Gasoline, Kitchen Grease Oil and Fats, Electric and Wood Fires for Home Apartment Office Student Boat RV Camping, 1-Pack MFF01

Fire drill onboard shipFire drill onboard crew on the image reserved the right owner

All of the above mentioned, is also applicable to other listed area base on fire ingredients present in that area.

Work and earn safe…. More videos and firefighting techniques could be found on our videos page, watch them to learn more.

Is this article useful to you? Do you think it will be useful for your friends? Share to reach them if yes.

Have more to contribute on source of fire? Please share with us on the comment box and subscribe below for more articles.

Leave a Comment

Discover more from Marine And Offshore Insight

Subscribe now to keep reading and get access to the full archive.

Continue reading